SUMMER SERVICES
PREVENTATIVE MAINTENANCE SERVICE
-
*Check battery connections, top off engine oil
*Run engine up in temperature, confirm water flow
*Test charging system
*Check for fuel, oil & water leaks
*Inspect belts, hoses & clamps
*Top off coolant & fluids
*Change spark plugs (carburetor engines only)
*Inspect distributor cap & rotor (replace if needed)
*Change fuel filters
*Confirm shift & throttle operations
*Check A/C output (generators)
4 Cylinder Engine……$325.00 Plus Parts
6 Cylinder Engine……$400.00 Plus Parts
8 Cylinder Engine……$440.00 Plus Parts
Generator…..……..….$310.00 Plus Parts
Change Spark Plugs on EFI/MPI .$85.00 Plus Parts
-
*Check battery connections
*Run engine up in temperature, confirm water flow
*Check telltale hose for blockage & clean
*Test charging system
*Confirm shift & throttle operations
*Inspect for fuel, oil & water leaks
*Change spark plugs
*Replace fuel filters
*Replace compressor air filter on Optimax engines
*Change/top-off gear oil
*Top off power trim & tilt fluid
*Grease prop shaft splines
Up to 10 HP Engine…..…..$165.00 Plus Parts
15 - 25 HP Engine...….....$180.00 Plus Parts
30 - 60 HP Engine………$190.00 Plus Parts
70 - 140 HP Engine………$225.00 Plus Parts
150 HP & Up Carbureted…$295.00 Plus Parts
EFI & Optimax…….……..$330.00 Plus Parts
-
*Check battery connections, top off engine oil
*Run engine up in temperature, confirm water flow
*Test charging system
*Check for water, fuel & oil leaks
*Inspect belts, hoses & clamps
*Confirm shift & throttle operations
*Change primary & secondary fuel filters
*Purge fuel system of all air
*Top off coolant & fluids
*Check A/C output (generators)
4 Cylinder Engine…….$235.00 Plus Parts
6 Cylinder Engine…….$435.00 Plus Parts
8 Cylinder Engine….....$545.00 Plus Parts
12 Cylinder Engine……$705.00 Plus Parts
Generators…..………....$270.00 Plus Parts
-
*Check battery connections, top off engine oil
*Run engine up in temperature, confirm water flow
*Check telltale hose for blockage & clean
*Test charging system
*Confirm shift & throttle operations
*Inspect for fuel, oil & water leaks
*Change spark plugs
*Replace fuel filters
*Change/top-off gear oil
*Top off power trim & tilt fluid
*Grease prop shaft splines
Up to 10 HP Engine…..……..$165.00 Plus Parts
15 - 25 HP Engine……..…..$185.00 Plus Parts
30 - 60 HP Engine…….…...$215.00 Plus Parts
70 - 140 HP Engine…..….….$260.00 Plus Parts
150 HP & Up ……………..…$325.00 Plus Parts
Verado L4………….………...$345.00 Plus Parts
Verado L6………....................$365.00 Plus Parts
V10 & V12…………………..$450.00 Plus Parts
*Oil & Filter Change (Upon Request) $80.00 Plus Parts
-
*Remove and reinstall outdrive
*Inspect u-joint, bellows & gimbal bearing
*Check engine alignment
*Change/top off gear oil
*Grease fittings & prop shaft splines
Mercury, Alpha I, Gen II, OMC….$300.00 Plus Parts
Bravo I, Bravo II……………….... $330.00 Plus Parts
Bravo III, King Cobra…………… $365.00 Plus Parts
TUNE UP SERVICES
-
*Check battery connections, top off engine oil
*Run engine up in temperature, confirm water flow
*Load test starting battery & test charging system
*Replace spark plugs
*Compression test all cylinders
*Replace spark plug wires (if needed)
*Replace distributor cap & rotor
*Adjust timing to specifications (if applicable)
*Check idle air control operation (EFI models)
*Check & adjust carburetor if needed
*Check & lube choke operations (if applicable)
*Replace all fuel filters
*Check all belts & hoses
*Top-off fluids & inspect for leaks
*Confirm & lube shift & throttle operations
4 Cyl Engine…………………$380.00 Plus Parts
6 Cyl Engine…………………$480.00 Plus Parts
8 Cyl Engine…………………$590.00 Plus Parts
EFI & MPI….………………..$655.00 Plus Parts
-
*Check battery connections, load test starting battery
*Run engine up in temperature, confirm water flow
*Test charging system
*Compression test all cylinders
*Replace spark plugs
*Replace all fuel filters
*Replace compressor air filter on Optimax engines
*Check all fuel hoses & fittings
*Check & adjust carburetors (if applicable)
*Synchronize linkages to timing marks
*Check timing marks & adjust if needed
*Confirm & lube shift & throttle operations
*Change gear oil
*Top off power trim & tilt fluid
*Grease all fittings & prop shaft splines
*Computer diagnostic scan on E.C.M. (if applicable)
Up to 10 HP Engine..………..$180.00 Plus Parts
15 - 25 HP Engine.………...$210.00 Plus Parts
30 - 60 HP Engine…..……..$260.00 Plus Parts
70 - 140 HP Engine…......…..$375.00 Plus Parts
150 HP & Up Carbureted……$460.00 Plus Parts
150 HP & Up EFI ………...…$500.00 Plus Parts
150 HP & Up Optimax….…...$540.00 Plus Parts
-
*Check battery connections, load test starting battery
*Top off engine oil
*Run engine up in temperature, confirm water flow
*Test charging system
*Compression test all cylinders
*Replace spark plugs
*Check all fuel hoses & fittings
*Replace all fuel filters
*Check & adjust carburetors (if applicable)
*Inspect timing belt, replace if needed
*Confirm & lube shift & throttle operations
*Change gear oil
*Top off power tilt & trim fluid
*Grease all fittings & prop shaft splines
*Computer diagnostic scan on E.C.M. (if applicable)
Up to 10 H.P. Engine………….$185.00 Plus Parts
15 - 25 H.P. Engine……..…..$225.00 Plus Parts
30 - 60 H.P. Engine………....$345.00 Plus Parts
70 - 140 H.P. Engine……........$500.00 Plus Parts
150 H.P. & Up (Non Verado)....$540.00 Plus Parts
Verado L4………..…............…$575.00 Plus Parts
Verado L6………….….....……$630.00 Plus Parts
Verado V8………….….....……$725.00 Plus Parts
Verado V10 & V12 .….....……$835.00 Plus Parts
*Oil & Filter Change (Upon Request)$80.00 Plus Parts
If valves need adjustment, customer
notified prior- Time plus Materials
OIL CHANGES
ALL INBOARD & STERN DRIVE ENGINES
Hourly Labor Plus Materials- Minimum 1 Hour Per Engine
Oil Disposal Fee………..…$2.50 Per Quart
FRESH WATER SYSTEM COMMISSIONING
*Flush nontoxic antifreeze from pumps & lines
*Pressurize system & check for leaks
*Inspect hot water tank & fittings for leaks
*Flush ice makers (if applicable)
*Test all sinks & spigots
*Prime freshwater toilets (if applicable)
Up to 24’……..………....…..$165.00
25’ - 35’…..……….…..……$275.00
36’ - 45’……………...….….$380.00
45’ & up………….…….…..$420.00
All Repairs Are Time Plus Materials
BOTTOM PAINT
Includes Labor & Materials
*Remove loose debris from hull
*Wipe down with acetone
*Tape off waterline
*Apply one coat ablative antifouling paint
Does not include removing and resetting on trailer.
Note: Specialty Paints are Available at an Additional Cost
-
Up to 28’…………………$35.00 Per Foot
29’ - 34’……….…………$40.00 Per Foot
35’ - 50’……….…………$45.00 Per Foot
51’ and Up……….………Labor Plus Materials
Remove loose debris from hull, wipe down with acetone,
tape off waterline, apply one coat ablative antifouling paint
Specialty Paints Available at Additional Cost
Does not include removing & resetting boat on trailer
-
Up to 25’………...$80.00 Per Foot
26’ & Up…. Call to schedule evaluation & estimate
Includes marking & taping new waterline, dewaxing, primer
coat & 2 coats ablative antifouling paint
Specialty Paints Available at Additional Cost
Does not include removing & resetting boat on trailer
-
Up to 22’…..……………..$260.00 Flat Fee
23’ - 29’…....…………….$390.00 Flat Fee
GELCOAT and FIBERGLASS REPAIRS
Hourly Labor Plus Materials
WASH, COMPOUND and WAX
Rub Rail to Waterline.. Includes Labor and Materials
Up to 32’…………………$35.00 Per Foot
33’ - 41’……….…………$40.00 Per Foot
42’ - 50’……….…………$45.00 Per Foot
51’ & up ………….………Call for pricing
LABOR RATES
-
*Hourly Rate..…………………...……..…….$165.00
*Minimum………………………..……….…....$85.00
*Overtime Rate (After 4:30PM)……$247.50
*Weekend Rate (4 Hour Minimum).$247.50
*Computer Diagnostic Scan ………...$165.00
*Estimates (Credited Towards Work)...$200.00
-
*Hourly Rate (Minimum Charge)….… $195.00
*Overtime Rate (After 4:30pm)…..… $292.50
*Weekend Rate (4 Hour Minimum)...$292.50
*Mobilization (Over 10 miles)…………..$150.00
Hourly Rate from Island Marine to Job Site & Back.
Add 20% and Mobilization Fee (if applicable) to all
Flat Rates for Mobile Service
EQUIPMENT RATES
100 Ton Railway $35.00 Per Foot LOA
*(Includes 10 Days on Rails, Water and Electricity)
Crane…$200.00 Per Hour Plus Labor (2 Person
Minimum)- $550.00 Minimum Fee
Work Boat..$200.00 Flat Fee Plus Labor (1 Person
Minimum)- $400.00 Minimum Fee
-
From Badger Island Marina to IMS
Includes Blocks and Stands
$14.50 Per Foot X L.O.A. Each Way
-
At Island Marine Service
$165.00 Flat Fee Each Way
-
(Boat Left On Hydraulic Trailer)
Up to 30’……..…..$14.50 Per Foot LOA
31’ – 40’…………$15.50 Per Foot LOA
SUMMER STORAGE
JUNE 1ST- SEPTEMBER 30TH
Boats at IMS Yard………..….$35.00 Per Foot LOA
Trailers……….....................$200.00 Flat Fee
**All trailers will require working tongue jacks**
2% of hourly labor costs will be added to invoice for shop supplies and consumables
$10.00 minimum charge
*Oil Disposal Fee………..…$2.50 Per Quart